50kw Rice Husk CHP System Low Consumption Biomass Generator / Power Generator

Product Description Equipment IntroductionThe 300 series biomass gas generator set, which uses waste rice husk, straw, wood and other agricultural and forestry wastes as raw materials, is pyrolyzed and gasified by biomass gasifier to produce combustible gas fueland drive the engine to work. Using rice husk, straw, wood flour and sawdust instead of expensive and tightpetroleum resources has good comprehensive economic benefits, and can also eliminate a large number of ricehusks and directly incinerate straw pollution to the environment. The development and utilization of biomass energy with modem technology is of great significance to the establishment of energy system for the sustainabldevelopment, the promotion of social economic development and the improvement of ecological environmeThe power range of 300 Series biomass gasification generator set is 400-1000 kw, and the technical reaches the advanced level in China.Technical Featuresa Single machine has high power with power range 400kw-1000kwm;Non-pressunzed natural suction, double-layer pipe intake system, and high resistance to tar;Removable intake valve box removable for convenient maintenance;Select extemal mixing or intemal mixing air intake system according to the hydrogen contentm;Adapt to low calorific biomass gas with high hydrogen contenta;High automation, high safety, and low operating cost.Application Gas Source RequirementsThe gas shall be dedusted, tar removed, desulphurized, dehydratedd cooled before entering the engine, and shall meet thefollowing requirements:Inlet gas temperature ≤ 40ºC Gas calorific value ≥ 4.0 mg/Nm3;Gas pressure 2.5-10 kpa;Pressure change rate ≤ 1 KPA / min;Water content ≤ 40 g/Nm3, no free water;Dust content ≤ 30 mg/Nm3;Dust particle size ≤ 5 μm;Tar content ≤ 50 mg/Nm3;Hydrogen sulfide content ≤ 50 mg/Nm3;Total sulfur content ≤ 100 mg/Nm3;  Technical specifications                                                   ItemTechnical specifications generator set Model of the Set        50GFLS Rated Power (KW)   50 Rated Voltage (KV)0.40.44Rated Current(A)  Rated Frequency(HZ)5060 Power Factor COS0.8 LaggingMode of Excitation Brushless Phase & Connection 3 Phases 4 Wires Generator Model  1FC6 SIEMENS Overall Dimensions(mm)6500X1830X3100Net Weight(kg)         22000engineModel of Engine    Mode                    Water cooling, four stroke, spark plug ignition, open combustion chamberNon Pressurization Arrangement of Cylinder Cyclinder Diameter(mm)300Stroke(mm)              380 Rated Power(kW)   440Speed(r/min)             Direction of rotation (from the end of the flywheel)        Counter Clock WiseStart-up Mode         Compressed AirExhaust temperature of each cylinder (ºC)         ≤580Gas inlet temperature (ºC)          ≤40Gas Pressure(kPa)   ≥2.5Oil Consumption(g/kWh)≤1.0     Product introduction The 300 series gas generator sets are widely used in clean energy power generation and comprehensive utilzation of waste heat, such as syngas, straw gas, coal gas, natural gas, biogas, blast furnace gas, coke ovenblue carbon gas, etc. The rotate speed is mainly at 500r / min and 60or / min, and the power ranges from400kw to 3000kw.The 300 series gas generator sets use vanous combustible gas as raw matenals for combustion to drive the engine to generate electricity. The engine is based on Xicha 300 diesel engine, combined with the advantages ofthe large cylinder bore and long stroke of 300 diesel engine. The generator sets have fully learned from theadvanced gas engine technology both at home and aboard. Targeted improvement and R & D have been conducted to meet the requirements of all kinds of combustible gas to ensure the combustion function andreliability of gas engine. In this case, the generator sets can run more smoothly and run for a longer penod underfull load. Moreover, the interconnection can be more convenient, and the comprehensive efficiency ofco-generation can be realized by utilizing waste heat. 300 senes gas generator sets can output at high, medium, and low voltage, achieve automatic parallel and grid connected, and have become the most popular exportedproducts among the same power.Technical FeaturesAs a medium speed gas power generation, 300 series gas engine set has obvious advantages compared with domestic similar products in practical application.Vailable for high , medium and low voltage output which reduces initial investment and operating costs 300 Senes gas generator sets can be customerized into different voltage output at 10500V, 6300V, and 400V, so that all kinds of requirements can be met and the intial investemnt of transformers can be avoided, contributng to the reducton of copper losses and operatng costs. Moreover, it can not only be connected to the grid, but also be used directly with load, which greatly improved the economic benefit of the genset.The output power of the set is ensured to be stable and steady with a large cylinder diameter and long stroke. The prime mover of 300 Series gas gener